Page 4 of 4
Jan 14th Post-Event - Ziptied Event on the Zip line
Posted: Tue Jan 17, 2017 9:40 pm
by twistedwankel
AScoda wrote:Itty bitty car has new itty bitty alternator held on by shiny new Schwarzenegger grade bolts.
Bottom bolt (the one the alternator pivots on) was pretty chewed up and it's mounting hole on the block is a bit more than round. Not sure what to do about that. I think the lower bolt was allowing some movement of the alternator which put stress on the upper mounting bolt attached to the tensioner that was beyond the capabilities of the bolt. Then, snap.
New lower bolt has far less movement and with everything torqued down, hopefully it will stay put. Added a couple of zip ties to keep tensioner in place if the bolt breaks again. Replaced upper bolt with grade 10.9 bolt which is the metric equivalent to Grade 8. We shall see.
It it's an aluminum block you are screwed. If it's cast iron you need a thread fixer thingie.
Jan 14th Post-Event - Ziptied Event on the Zip line
Posted: Tue Jan 17, 2017 9:41 pm
by Lava Speed 05
twistedwankel wrote:Lava Speed 05 wrote:Missing those events in the beginning of the season is killing my chances of a T-shirt, well that and my driving... I know someone in another class needs Joe to co-drive with them.
Sent from my Pixel XL using Tapatalk
Joe B destroyed SCCA B Street in my B Street car with worn 240 tires in 2016. What would he do with RE71's in 2017? Be careful what you wish for. Joe can run any car in M2....even an S2 car with a new Exedy clutch/flywheel. Drew beat you all with an old slipping clutch in the same car on the same tires not long ago in 2016. Yowser.
Joe vs Drew vs Matt vs Doug? Been there done that. Drew won.
Yeah but with Drew playing in M0 and if Joe had played in stock class, the rest of us mortals had a chance... It just wasn't meant to be.
Sent from my Pixel XL using Tapatalk
Jan 14th Post-Event - Ziptied Event on the Zip line
Posted: Tue Jan 17, 2017 9:52 pm
by twistedwankel
Point is those two guys would win M classes in stock S cars. It's not over until it's over. Don't hear a fat lady singing. Are you the fat lady now?
Jan 14th Post-Event - Ziptied Event on the Zip line
Posted: Tue Jan 17, 2017 9:55 pm
by Lava Speed 05
Michelle did buy me exercise equipment for Christmas so I must be getting close...
Sent from my Pixel XL using Tapatalk
Jan 14th Post-Event - Ziptied Event on the Zip line
Posted: Tue Jan 17, 2017 9:57 pm
by twistedwankel
Ron is going to drive my wife's 93 Crown Vic at the next Classic @ the Dog Track. Because she says he can. Maybe wife will ride with him in luxury? It's been so long since we had a run off between Brian and Ron with a full house at a Classic in a four door. That will be fun to watch. No contest for me against those guys.
Jan 14th Post-Event - Ziptied Event on the Zip line
Posted: Tue Jan 17, 2017 10:24 pm
by AScoda
The only threaded part is on the alternator. Bolt just goes through a hole that it's been wiggling around in some. Could drill it round again and sleeve it, or use a bolt with a bigger shank and thread it down for the alt or drill and tap the alt hole larger. It's fixable if it's going to be a problem.
Jan 14th Post-Event - Ziptied Event on the Zip line
Posted: Tue Jan 17, 2017 10:50 pm
by Loren
Drew, the hole in question is on a bracket that's bolted to the block. You could replace it if you had to. On earlier Miatae, that bracket is cast iron. I believe yours is aluminum. Held on by 3-4 bolts.
But, if you've got the pivot bolt good and tight, it shouldn't be a problem.
Jan 14th Post-Event - Ziptied Event on the Zip line
Posted: Wed Jan 18, 2017 8:27 am
by Blue_Heron
Lava Speed 05 wrote:
Yeah but with Drew playing in M0 and if Joe had played in stock class, the rest of us mortals had a chance... It just wasn't meant to be.
Exactly why I moved to S5.
Jan 14th Post-Event - Ziptied Event on the Zip line
Posted: Thu Jan 19, 2017 6:38 pm
by Rawkkrawler
Lava Speed 05 wrote:
Yeah but with Drew playing in M0 and if Joe had played in stock class, the rest of us mortals had a chance... It just wasn't meant to be.
What i just heard is that we should kick Drew out of M0, let's do that!
Jan 14th Post-Event - Ziptied Event on the Zip line
Posted: Thu Jan 19, 2017 6:40 pm
by Loren
You know, one of these days we're gonna get a wild hair and put a 1.8 into the FASTiva and run M0. We'd have to replace the transmission every few months, but it might be worth it.
Jan 14th Post-Event - Ziptied Event on the Zip line
Posted: Thu Jan 19, 2017 7:24 pm
by AScoda
<sadface>
Jan 14th Post-Event - Ziptied Event on the Zip line
Posted: Thu Jan 19, 2017 8:21 pm
by Lava Speed 05
AScoda wrote:<sadface>
We're sorry Drew, it's not your fault we suck... [emoji23]
Sent from my Pixel XL using Tapatalk
Jan 14th Post-Event - Ziptied Event on the Zip line
Posted: Thu Jan 19, 2017 9:53 pm
by twistedwankel
Drew's so fast he breaks alternator bracket bolts. That's darn fast.
